Just about all BMWs are now being engineered with a sunken nut input flange on the differential. (See picture) Unfortunately, the seals behind this are becoming commonplace to leak. This configuration requires special tooling in order to successfully replace the seals without damaging the input shaft bearing. The first step requires the removal of the [...]
With ever increasing demands for fuel efficiency and power, modern combustion engines are now direct fuel injected. This means the tip of the injector lies in the combustion chamber for the fuel to be injected directly where it is required for minimum waste and maximum efficiency. Unfortunately, the side effect of this is that the [...]
M-Power, the pinnacle of the BMW marque. The perfect blend of power, agility and refinement. Munich Power are specialists in the maintenance, repair and modification of M-Power vehicles. Countless M-cars pass through our doors for a huge variety of work. E46 Rear axle carrier panel repairs. S54 Vanos rebuilds E46 SMG II repairs [...]
Traction control isn't anything new to BMW's, in fact, it's been a part of BMW's make up for nearly 30 years. Despite this, with the ever changing industry, the systems now, although similar in function, holds very little resemblance to the systems of old. The DSC hydraulic unit is a particular weak spot of the E89x [...]
The BMW N43 engine is a 4 cylinder petrol unit found in a huge amount of 1 and 3 series vehicles built between 2007 and 2013 Unfortunately, these engines can suffer from a stretched timing chain. Which can subsequently destroy your engine or even prevent your brakes from working correctly. When the chain stretches, the plastic chain [...]
Automatic transmissions have developed tremendously over the last few years. 8-speed gearboxes are now commonplace among BMWs. This means the engine is always able to be in the optimum gear for maximum efficiency or power (depending on the load requirement at any given time) Normally a BMW Automatic gearbox is pretty reliable. However, occasionally they can be [...]
A well documented issue with BMW 4 cylinder diesel engines is a failure of the timing chain. Stretched, or even broken chains can cause catastrophic engine damage. A symptom can include an unpleasant noise from the engine. However, sometimes sudden failure can occur leaving the owner with a non-running car, huge inconvenience and large repair bills. As with [...]
A common issue with the Car Communication Computer (CCC) is the DVD drive failing and not recognising the Sat Nav disc. We're able to repair this fault, dissembling the CCC and replacing the internal DVD drive. Saving customers hundreds of pounds over a replacement CCC.
A common problem with the 1 series and 3 series is corrosion on the driveshaft reluctor ring. This distortion destroys the wheel speed sensor signal and plays havoc with the traction control system. A new driveshaft or reluctor ring and a new wheel speed sensor will rectify this issue. We can carry out this repair [...]